G62 at the ASZ in the Seat Ibiza

23-01-2011, 19:08 Subject: G62 at the ASZ in the Seat Ibiza

Hello everyone!
I'm having a problem where my coolant temperature sensor occasionally shorts out, which causes an error to be logged in the MSG (presumably a vehicle's diagnostic system). Furthermore, I've also noticed a slightly increased fuel consumption since the error started.
I wanted to replace this part now (I have a replacement ready), but I can't find it anywhere. Unfortunately, the Ibiza also has a very cramped engine compartment.
I would really appreciate it if someone could locate the G62 in the attached images, so I know exactly where to look.

Thank you in advance!

23-01-2011, 20:06 Subject: G62 at the ASZ in the Seat Ibiza

Hello,

It is located on the rear right side of the cylinder head and has a 4-pin connector.

Best regards, Rainer.

23-01-2011, 21:55 Subject: G62 at the ASZ in the Seat Ibiza

and it's really not possible to swap the gift. Look at it with a mirror, angled slightly below the tandem pump. It's installed facing in the direction of travel. Be careful with the retaining clip. If it falls off, you'll need to remove the lower engine cover.

Have fun.

24-01-2011, 17:38 Subject: G62 at the ASZ in the Seat Ibiza

dieselschrauber wrote:

It is located on the rear right side of the cylinder head

, as viewed from the front

.

Quote:

and has a 4-pin connector.

No, only 2-pin! The AI receives the water temperature data from the MSG via CAN.

24-01-2011, 18:55 Subject: G62 at the ASZ in the Seat Ibiza

Quote:

No, only 2-pole! The AI receives the WaTemp data from the MSG via CAN.

Oh, thank you for the information!

Fortunately, none of the newer models have failed on me yet.