VCDS and OBD diagnostic device in the On-Board Diagnostics Shop
Diesel, Engine Technology and Vehicle Technology. Repair, Maintenance and Diagnostics (OBD).

Front Wheel Squeal When Turning

 
New Topic Reply 🔗 ⭐ 🖨 Dieselschrauber - Index » Transmission, Chassis, Body & Interior
Author Message
donalexo
Profi-Schrauber
Profi-Schrauber


Joined: 01/08/2003
Posts: 695
Karma: +0 / -0   Thank you, like it!
Location: Würzburg

Support

Post06-04-2003, 0:29    Subject: Front Wheel Squeal When Turning Quote

Hello fellow DIY enthusiasts!
My Audi A3 has been making noises when the front suspension compresses for at least 2 years. However, this noise only occurs at higher outdoor temperatures and low humidity.
It sounds absolutely terrible, like an old barn door, when the front wheels compress.
During the second-to-last service appointment, I brought the problem to the attention of the service department. Unfortunately, it was raining that day, so the noise was no longer present. Consequently, Audi was unable to provide any assistance.
Once, I myself pulled and pushed on the front axle's anti-roll bar stabilizer with all my strength, even though the wheels were fully turned. I believe that the rubber bushings of the stabilizer link between the stabilizer and the control arm might be the cause, but I'm not entirely sure.
What do the professional thieves in this forum think about this? Are there any other A3 owners here with similar problems?
What can be done to eliminate the noise? Should I replace the bearings, or is there a cheaper solution?
I was thinking that if they are rubber bushings, maybe spraying them with Teflon or silicone spray might help eliminate the squeaking. Has anyone had any experience with this?

Thank you for your help.

Regards,
Alex.
AUDI A3 1.9 TDI, EZ 12/96, ursprüglich MKB AGR, umgebaut zum AHF mit GT1749V-Lader, verkauft mit 250tkm

Golf 4 1.9 TDI, EZ 1/98, MKB ALH, jetzt auch mit GT1749V-Lader, verkauft mit 300tkm

Touran 1.9 TDI, EZ 09/2004

Audi A4 Avant 2.0 TDI, EZ 03/2010


Translated on 22-10-2026, 0:51.
Back to top Profile PM
98er_alh
Blaumann
Blaumann


Joined: 02/24/2003
Posts: 56
Karma: +6 / -0   Thank you, like it!


Support

Post08-04-2003, 18:27    Subject: Front Wheel Squeal When Turning Quote

In my case (my Golf IV), it was the rear rubber bushings of the control arms – specifically, the ones located in the estimated 8cm opening. I "treated" them with grease spray, and everything is okay now. Apparently, these elements expand and rub inside the opening. If you're not sure what I'm talking about, I can also email you a picture.

Best regards,
Andreas


Translated on 22-10-2026, 0:54.
Back to top Profile PM
donalexo
Profi-Schrauber
Profi-Schrauber


Joined: 01/08/2003
Posts: 695
Karma: +0 / -0   Thank you, like it!
Location: Würzburg

Support

Post08-04-2003, 18:47    Subject: Front Wheel Squeal When Turning Quote

Thank you for your offer to provide the pictures; that would certainly be helpful.

Oh, by the way, what kind of grease did you actually use? Was it a silicone-based or Teflon-based grease? Do you think you could also use a universal lubricant, like Caramba Super Multi-Oil?
I simply want to prevent the lubricant from degrading the rubber bushing over time. On the other hand, it should be a lubricant that doesn't get washed away after just a few hundred kilometers, otherwise the play would start all over again.
AUDI A3 1.9 TDI, EZ 12/96, ursprüglich MKB AGR, umgebaut zum AHF mit GT1749V-Lader, verkauft mit 250tkm

Golf 4 1.9 TDI, EZ 1/98, MKB ALH, jetzt auch mit GT1749V-Lader, verkauft mit 300tkm

Touran 1.9 TDI, EZ 09/2004

Audi A4 Avant 2.0 TDI, EZ 03/2010


Translated on 22-10-2026, 0:55.
Back to top Profile PM
Schwob
Guest




 


Free account, no CAN development support

Post09-04-2003, 18:57    Subject: Front Wheel Squeal When Turning Quote

'With my Passat, I experienced the same issue, except there were also noises when turning the steering wheel. In my case, it was a faulty tie rod end.'


Translated on 22-10-2026, 0:55.
Back to top
donalexo
Profi-Schrauber
Profi-Schrauber


Joined: 01/08/2003
Posts: 695
Karma: +0 / -0   Thank you, like it!
Location: Würzburg

Support

Post28-04-2003, 22:50    Subject: Front Wheel Squeal When Turning Quote

@schwob
I probably got my hopes up too soon. After the grease spray treatment on several rubber bushings in the front suspension, things were quiet for a while. But this afternoon, I noticed a noise again, and it had a completely different sound than the noises I'd heard before.
I suspect that the noise so far has been a combination of several sources. After the rubber bushings were silenced, only a metallic-sounding noise remains. It could also be a ball joint that is starting to fail and making grinding noises! I will re-examine the issue.

Regards,
Alex.
AUDI A3 1.9 TDI, EZ 12/96, ursprüglich MKB AGR, umgebaut zum AHF mit GT1749V-Lader, verkauft mit 250tkm

Golf 4 1.9 TDI, EZ 1/98, MKB ALH, jetzt auch mit GT1749V-Lader, verkauft mit 300tkm

Touran 1.9 TDI, EZ 09/2004

Audi A4 Avant 2.0 TDI, EZ 03/2010


Translated on 22-10-2026, 0:56.
Back to top Profile PM
New Topic Reply 🔗 ⭐ 🖨 Dieselschrauber - Index » Transmission, Chassis, Body & Interior
Similar articles and topics
Topic Forum
No new posts Front Wheel Bearing Noise (Golf 4) Faults & Documentation (Audi, VW, Seat/Cupra, Skoda)
No new posts Document 1J, Clicking, Squeaking at the rear axle Faults & Documentation (Audi, VW, Seat/Cupra, Skoda)
No new posts 2.0 TDI BKD/AZV from 2004, Whistling/Squealing noise unde... Faults & Documentation (Audi, VW, Seat/Cupra, Skoda)
No new posts Clutch Squeal: Causes and Solutions Diesel Engine Technology
No new posts Clutch pedal squeak Diesel Engine Technology
No new posts Car Noises: Squeaks and Chirps from the Front Transmission, Chassis, Body & Interior
No new posts Steering Noise: Causes and Solutions Transmission, Chassis, Body & Interior
Jump to:  
You cannot post new topics in this forum.